文章摘要
梁宁,郭彦峰,王冬梅,杨瑞.蜂窝纸板振动传递特性的有限元仿真分析[J].包装工程,2019,40(1):57-62.
LIANG Ning,GUO Yan-feng,WANG Dong-mei,YANG Rui.Finite Element Simulation on Vibration Transmissibility for Honeycomb Paperboard.Packaging Engineering,2019,40(1):57-62.
蜂窝纸板振动传递特性的有限元仿真分析
Finite Element Simulation on Vibration Transmissibility for Honeycomb Paperboard
投稿时间:2018-06-05  修订日期:2019-01-10
DOI:10.19554/j.cnki.1001-3563.2019.01.008
中文关键词: 蜂窝纸板  有限元法  共振频率  振动传递率
英文关键词: honeycomb paperboard  finite element method  resonance frequency  vibration transmissibility
基金项目:国家自然科学基金(51675349)
作者单位
梁宁 1.西安理工大学西安 7100482.深圳职业技术学院深圳 518055 
郭彦峰 1.西安理工大学西安 710048 
王冬梅 2.深圳职业技术学院深圳 518055 
杨瑞 1.西安理工大学西安 7100482.深圳职业技术学院深圳 518055 
摘要点击次数: 18
全文下载次数: 47
中文摘要:
      目的 针对蜂窝纸板的振动防护性能,研究不同结构和材料参数的蜂窝纸板振动传递特性的有限元仿真分析方法。方法 利用有限元软件Abaqus/Standard建立蜂窝纸板-质量系统模型,设定2种蜂窝纸板,分别具有不同的面纸材料参数和蜂窝胞元边长。仿真分析蜂窝纸板的振动传递特性,并对其进行实验验证。结果 通过仿真和实验得到了蜂窝纸板的振动传递率-频率曲线,共振频率的仿真结果与实验值误差小于3.43%,共振时振动传递率的仿真结果与实验值误差小于11.31%。结论 利用该有限元仿真方法,能够获得不同结构和材料参数的蜂窝纸板的振动传递特性。仿真分析结果表明,面纸定量对蜂窝纸板振动传递特性的影响不大,而蜂窝胞元边长较大的蜂窝纸板,其系统共振频率较小,振动传递率变化不明显。
英文摘要:
      The work aims to study the finite element simulation analysis method for vibration transmissibility of honeycomb paperboard with different structural and material parameters, with respect to the vibration protection performance of honeycomb paperboard. Based on the finite element software Abaqus/Standard, the honeycomb paperboard-mass system model was established. Then, two kinds of honeycomb paperboards were set up with different liner material parameters and honeycomb cell side length. The vibration transmissibility of honeycomb paperboards was analyzed by simulation and verified by experiments. The vibration transmissibility-frequency curve of honeycomb paperboard was obtained through simulation and experiment. The error between the simulation result of resonance frequency and the experimental value was less than 3.43%, and the error between the simulation result of vibration transmissibility and the experimental value during resonance was less than 11.31%. The finite element simulation method can be used to obtain the vibration transmissibility of honeycomb paperboard with different structural and material parameters. Moreover, the simulation analysis results show that the effect of liner grammage on vibration transmissibility of honeycomb paperboard is small, while the resonance frequency of system of honeycomb paperboard with larger honeycomb cell length is smaller, yet the change of vibration transmissibility is not obvious.
查看全文   查看/发表评论  下载PDF阅读器
关闭

关于我们 | 联系我们 | 投诉建议 | 隐私保护 | 用户协议

您是第5235651位访问者    渝ICP备10003521号-2

版权所有:《包装工程》编辑部 2014 All Rights Reserved

邮编: 电话:023-68792294传真: Email:

    

渝公网安备 50010702501716号